Drying studies in Indian bay leaf (Cinnamomum tamala (Buch.-Ham.) T. Nees & Eberm) under warm and humid conditions of the Bay Islands: Drying studies in Indian bay leaf

Sohini Ghosh; Ajit Arun Waman; Pooja Bohra; R Karthika Devi

doi:10.25081/josac.2025.v34.i1.9775

Authors

Sohini Ghosh School of Life Sciences, Garden City University, Bengaluru, Karnataka, Division of Horticulture and Crop Improvement, ICAR- Central Island Agricultural Research Institute, Sri Vijaya Puram, Andaman and Nicobar Islands
Ajit Arun Waman Division of Horticulture and Crop Improvement, ICAR- Central Island Agricultural Research Institute, Sri Vijaya Puram, Andaman and Nicobar Islands
Pooja Bohra Division of Horticulture and Crop Improvement, ICAR- Central Island Agricultural Research Institute, Sri Vijaya Puram, Andaman and Nicobar Islands
R Karthika Devi Division of Horticulture and Crop Improvement, ICAR- Central Island Agricultural Research Institute, Sri Vijaya Puram, Andaman and Nicobar Islands

DOI:

https://doi.org/10.25081/josac.2025.v34.i1.9775

Keywords:

Chlorophyll, tejpat, tree spice, quality

Abstract

Indian bay leaf or tejpat (Cinnamomum tamala (Buch.-Ham.) T. Nees & Eberm) is an important spice that has been used for flavouring of cuisines and as an ingredient in pharmaceutical and allied industries. At present, the leaves are largely harvested from the trees grown in the backyards or from the wild and dried under the sun or shade in most of the growing areas. However, as the cultivation of the crop is also extending in non-native regions of this crop including the Bay Islands, identification of region-specific method of drying was envisaged. In the present study, five drying methods viz. vacuum drying, sun drying, oven drying (45 °C and 55 °C) and air drying were compared to know their effect on quality parameters of tejpat under island conditions. Moisture content in the fresh samples was 49.89%, which was reduced to 4.54% (sun drying) to 6.78% (air drying). The dry recovery was found to be the highest in air drying. Oleoresin content was highest in the sun drying method, while essential oil content did not vary. Chlorophyll a, chlorophyll b and total chlorophyll content were found to be the highest in air dried samples, which remained on par with vacuum drying. Total carotenoids content was the highest in case of vacuum drying. RHS colour chart codes exhibited variations among the dried produce. Considering the better dry recovery, better retention of chlorophyll content and ease of operation, air drying could be recommended for farm level processing of tejpat under warm and humid areas. In the times of high rainfall and humidity, mechanical drying could be adopted to facilitate better drying.

Downloads

Download data is not yet available.

References

AOAC 2005 Official Methods of Analysis, 18th Ed., AOAC International, Rockville, MD.

Attri D C, Bahukhandi A, Trivedi V, Chauhan RS, Nautiyal MC & Nautiyal BP 2024 Variation in the essential oil composition in leaves (fresh & dried) of Cinnamomum tamala (Indian bay leaf) cultivated in Western Himalaya. Natl. Acad. Sci. Lett. 47(6):701–704. https://doi.org/10.1007/s40009-024-01416-1

Calin-Sanchez A, Szumny A, Figiel A, Jaloszynski K, Adamski M & Carbonell-Barrachina A A 2011 Effects of vacuum level and microwave power on rosemary volatile composition during vacuum-microwave drying. J. Food Eng. 103(2): 219-227.

Choe E & Min D B 2006 Mechanisms and factors for edible oil oxidation. Compr. Rev. Food Sci. Food Saf. 5(4): 169–186.

Diaz-Maroto M C, Perez-Coello M S & Cabezudo M D 2002 Effect of drying method on the volatiles in bay leaf (Laurus nobilis L.). J. Agric. Food Chem. 50: 4520-4524.

Fiana R M, Ningsih W S, Abdi, Syukri D & Indeswari N S 2024 Characteristics of chemical components and organoleptic tests of Cinnamon leaf tea against differences in time and temperatures. Food Sci. Technol. 12(1): 94-104.

Garusinghe D M P M, Lee F S & Thoo Y Y 2023 Efficacy of green solvents in pungent, aroma and colour extractions of spice oleoresins and impact on phytochemical and antioxidant capacities. Food Biosci. 56: 103171.

Gaur R D 2008 Traditional dye yielding plants of Uttarakhand, India. Nat. Prod. Res. 7(2): 154-165.

Ghasem M, Ebadi M T & Ayyari M 2020 Qualitative changes of spearmint essential oil as affected by drying methods. Ind. Crop. Prod. 153: 112492. https://doi.org/10.1016/j.indcrop.2020.112492

Gwari G, Bhandari U, Naik G, Haider S Z & Chauhan N 2016 Genetic diversity in Cinnamomum tamala Nees. accessions through DNA fingerprinting using molecular markers. Ind. J. Agric. Res. 50(5): 446-450.

Hamrouni-Sellami I, Rahali F Z, Rebey I B, Bourgou S, Limam F & Marzouk B 2013 Total phenolics, flavonoids, and antioxidant activity of sage (Salvia officinalis L.) plants as affected by different drying methods. Food Bioprocess Technol. 6(3): 806-817.

Jayashree E, Visvanathan R & Zachariah T J 2014 Quality of dry ginger (Zingiber officinale) by different drying methods. J. Food Sci. Technol. 51(11): 3190–3198. https://doi.org/10.1007/s13197-012-0823-8

Kotteswari M, Rao M R K, Kumar S, Prabhu K, Sundaram R L & Dinakar S 2018 GCMS analysis of one ayurvedic preparation ‘Aswagandharishtam’. Biomed. Pharmacol. J. 11(2): 1061-1072.

Lamichhane D & Karna N K 2009 Harvesting methods of Cinnamomum tamala leaves in private land: a case study from Udayapur district, Nepal. Banko Janakari 19(2): 20-24.

Okos M, Campanella O, Narsimhan G, Singh R K & Weitnauer A C 2007 Food dehydration. In: Heldman DR, Lund DB (eds) Handbook of food engineering, 2nd edn. CRC Press, Boca Raton, pp 601-744.

Orphanides A, Vlasios G & Gekas V 2016 Drying technologies: vehicle to high-quality herbs. Food Eng. Rev. https://doi.org/10.1007/s12393-015-9128-9

Phondani P C, Bhatt I D, Negi V S, Kothyari B P, Bhatt A & Maikhuri R K 2016 Promoting medicinal plants cultivation as a tool for biodiversity conservation and livelihood enhancement in Indian Himalaya. J. Asia-Pacific Biodiv. 9: 39-46.

Priyanka G D, Ghosh S, Devi R K & Waman A A 2022 Effect of Drying Methods on Quality Parameters of Lemon Grass (Cymbopogon flexuosus) Var. OD-19. J. Andaman Sci. Assoc. 27(2): 204-209.

Procopio F R, Ferraz M C, Paulino B N, Sobral T J A & Hubinger M D 2022 Spice oleoresins as value added ingredient for food industry: recent advances and perspectives. Trends Food Sci. Technol. 122: 123-139.

Rahimmalek M & Goli S H 2013 Evaluation of six drying treatments with respect to essential oil yield, composition and color characteristics of Thymys daenensis sub. sp. daenensis. Celak leaves. Ind. Crop. Prod. 42: 613-619. https://doi.org/10.1016/j.indcrop.2012.06.012

Rani A, Pande C, Tewari G & Patni K 2017 A review on aroma profile of Cinnamomum species in North and North East India. World J. Pharm. Res. 6: 200-221.

Rao L J, Singh M, Raghavan B & Abraham K O 1998 Rosemary (Rosmarinus officinalis L.): Impact of drying on its flavour quality. J. Food Qual. 21(2): 107–215. https://doi.org/10.1111/j.1745-4557.1998.tb00508

Saha S & Mitra A 2024 Seasonal and diurnal variations in leaf aroma volatiles of Cinnamomum tamala (Buch.—Ham.) T. Nees & Eberm as evidenced from metabolite profiling, histochemical and ultrastructural analyses. Tree Physiol. 44: tpae138 https://doi.org/10.1093/treephys/tpae138

Saha S, Bhattacharya R, Dey P K & Mitra A 2024 Comparative assessment of essential oil composition and yield in Cinnamomum tamala leaves upon application of different drying practices. J. Essen. Oil Res. 36(4): 395-406. https://doi.org/10.1080/10412905.2024.2350409

Schaarschmidt S 2016 Public and private standards for dried culinary herbs and spices—part I: Standards defining the physical and chemical product quality and safety. Food Control 70: 339–349. https://doi.org/10.1016/j.foodcont.2016.06.004

Sefidkon F, Abbasi K & Khaniki G B 2006 Influence of drying and extraction methods on yield and chemical composition of the essential oil of Satureja hortensis. Food Chem. 99(1): 19–23.

Sharma V & Rao L J M 2014 An overview on chemical composition, bioactivity and processing of leaves of Cinnamomum tamala. Crit. Rev. Food Sci. Nutr. 54: 433-448, https://doi.org/10.1080/10408398.2011.587615

Sowbhagya H. 2019 Value-added processing of by-products from spice industry. Food Qual. Saf. 3(2): 73-80.

Tansura M, Tabassum F, Alam K M M & Uddin M A 2024 Seasonal dynamics of phytochemicals in Cinnamomum tamala (Buch.-Ham.) Nees and Eberm. (Tejpata). Int. J. Med. Plants Nat. Prod. 10(1): 31-45. https://doi.org/10.20431/2454- 7999.1001004

Waman A A & Bohra P 2021 A novel approach for round the year propagation of Cinnamomum tamala (Buch.-Ham.) T. Nees. &Eberm. through air layering. J Plant. Crops 49(3): 222-224. https://doi.org/10.25081/jpc.2021.v49.i3.7457

Waman A A 2022 Promoting Indian Bay Leaf in the Andaman Islands through Quality Planting Material. Indian J. Arecanut Spices Med. Plants 24(3): 16-18.

Waman A A, Bohra P & Devi K R 2024b Biochemical studies in woody pepper (Piper pendulispicum C.DC.): A spice with edible stem from Andaman Islands, India. Ann. Phytomed., 13(1): 1141-1148. http://dx.doi.org/10.54085/ap.2024.13.1.122

Waman A A, Bohra P & Devi R K 2020 Performance of improved varieties of true Cinnamon (Cinnamomum verum J. Presl.) in Andaman Islands, India. Pantnagar J. Res. 18(3): 243-248.

Waman A A, Bohra P, Devi K R, Lokesha A N & Shivashankara K S 2024a Stem of Woody Pepper (Piper pendulispicum C. DC) as a Source of Phenolic Acids and Piperine. Indian J. Plant Genet. Resour. 37(2): 294-300. DOI: 10.61949/0976-1926.2024.v37i02.12

Wellburn A R 1994 The spectral determination of chlorophylls a and b, as well as total carotenoids, using various solvents with spectrophotometers of different resolutions. J. Plant Physiol. 144: 307-31.

Drying studies in Indian bay leaf (Cinnamomum tamala (Buch.-Ham.) T. Nees & Eberm) under warm and humid conditions of the Bay Islands